Safety defect investigations, technical specifications, and manufacturer repair notices for Canadian owners.
Enter a VIN to identify your vehicle and find Canadian recall notices that may apply to its make, model and year. Confirm VIN-specific eligibility and repair status with the manufacturer.
Switch to another Chevrolet Bolt Ev model year.
Safety recall notices and repair campaigns registered for the 2018 Chevrolet Bolt Ev in Canada.
On certain vehicles, the recall repairs may not have been completed by a General Motors dealer during recall N222383790 and/or N222383791 (Transport Canada recall number 2022-719). As a result, a second inspection is required. On certain vehicles, the carpet could catch fire after a crash where a front seat belt pretensioner deploys.
A fire that occurs after a crash could create an increased risk of injury.
General Motors will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, install foil tape under the carpet near the front seatbelt pretensioners. On certain model year vehicles, the technician will also install seatbelt pretensioner covers.
On certain vehicles, the carpet could catch fire after a crash where a front seat belt pretensioner deploys.
A fire that occurs after a crash could create an increased risk of injury.
General Motors will notify owners by mail and instruct you to take your vehicle to a dealership to install foil tape under the carpet near the front seatbelt pretensioners. On certain model year vehicles, the technician will also install seatbelt pretensioner covers.
This recall is for certain driver's all-weather floor liners sold with new vehicles or as accessory parts sold at General Motors dealerships. On certain vehicles, the accelerator pedal could get stuck on the floor liner. If this happens, the vehicle may not slow down when you release the accelerator pedal. Note: If you continue to push the brake pedal, the brake-override system will allow you to stop the vehicle.
A stuck accelerator pedal could lead to unintended acceleration and increase the risk of a crash.
General Motors will notify owners by mail and instruct you to take your vehicle to a dealer to replace the driver's all-weather floor liner. You should remove the all-weather floor liner until you receive the replacement part.
On certain vehicles, the high-voltage battery could overheat when it is charged to over 90% of its capacity. As a result, the battery could create smoke or heat, which can melt or damage the battery and nearby parts.
A battery that overheats can create a fire risk.
General Motors will notify owners by mail and replace defective battery modules. Until replacement battery modules are available, General Motors recommends the following: 1. Enable "Hilltop Reserve" (for 2017-2018 models) or "Target Charge Level" (for 2019 models) using the vehicle's infotainment centre to limit the state of charge to 90%. If you are unable to make these changes, or do not feel comfortable making them, you should visit a dealer to have these adjustments completed. 2. Charge your vehicle more frequently and avoid depleting the battery below approximately 113 km (70 miles) of remaining range, where possible. 3. Out of an abundance of caution, park your vehicle outside immediately after charging and not leave vehicle charging indoors overnight. Please click here for additional information, or call 1-800-263-3777 : https://my.gm.ca/chevrolet/en/how-to-support/safety/boltevrecall Note: All vehicles must also have Transport Canada Recall # 2020-540 completed.
On certain vehicles, a problem with the rear brake system may cause gas bubbles to form in the brake fluid. This could cause a soft brake pedal feel and a reduction in brake performance, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will bleed the rear brakes.
A failure of this component (brakes) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
Certain vehicles may experience front windshield wiper stall during cold, snowy conditions due to a software error. If one or both windshield wipers were to stall, this could limit the driver's visibility, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the front wiper motors with wiper motors containing improved software.
A failure of this component (visual system) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
Official Transport Canada safety campaigns, Canadian motor vehicle safety compliance standards and live VIN specifications.
Explore safety recall records by model year.