2021 Fleetwood Rv Flair Recall

On certain motorhomes, the exterior patio 120 V electrical outlet doesn't have ground-fault circuit interrupter (GFCI) protection.

An electrical outlet that doesn't have ground-fault protection could create a risk of shock or electrocution.

To reduce the safety risk, REV Group advises you to only use the exterior patio outlet when it's powered by invertor power until the recall repairs are completed. REV Group will notify owners by mail and advise you to take your motorhome to a dealership to install ground-fault protection to the exterior patio outlet.

On certain motorhomes, the front overhead cabinet under the drop-down bed may not be properly attached. As a result, the cabinet could detach and fall on the driver and/or passenger. Note: This recall only affects motorhomes with an optional Happijac drop-down bed.

A cabinet that detaches and falls could create a risk of injury. Additionally, a cabinet that falls while driving could create a distraction and/or affect a driver's visibility, increasing the risk of a crash.

To reduce the safety risk, REV Group advises you to remove all contents from the front overhead cabinet and to inspect that the cabinet isn't starting to detach until the recall repairs are completed. REV Group will notify owners by mail and advise you to take your motorhome to a dealership to reinstall the front overhead cabinet with additional hardware.

On certain motorhomes, the service valve (main shutoff) for the propane tank may be defective. As a result, the connector may not seal properly and could leak propane.

A propane gas leak could create the risk of a fire or explosion.

REV Group will notify owners by mail and instruct you to take your motorhome to a dealership to perform a leak test and inspect the date code on the service valve. It will be replaced, if necessary. REV Group recommends that you should shut off the service valve (main shutoff) on the propane tank until your motorhome is inspected.

On certain motorhomes, the hoses for the hydraulic leveling jack system may not be routed, secured, or protected correctly. As a result, the hoses could be damaged by heat and/or contact with the frame. If this happens, hydraulic fluid could leak.

A hydraulic fluid leak could increase the risk of a fire.

REV Group will notify owners by mail and instruct you to take your motorhome to a dealership to inspect and, if necessary, repair or replace the hoses for the hydraulic leveling jack system.

On certain motorhomes, the rear axle was not properly filled with oil. Operating the vehicle like this could result in damage to the rear axle bearings that can cause them to seize. If that happens, the rear axle or driveshaft could fail, causing a loss of power to the wheels. Additionally, a vehicle with a rear axle or driveshaft failure may also move when the transmission is in Park, even if the parking brake is applied.

A loss of power to the wheels could increase the risk of a crash. A parked vehicle that rolls away could also increase the risk of an injury or a crash.

REV RV will notify owners by mail and instruct you to take your motorhome to a Ford dealer to inspect the oil level in the rear axle. The rear axle bearings will be replaced, if necessary.

On certain motorhomes equipped with a Dometic propane gas stove, there could be an odour of propane gas after a short period of use. If a user attempts to tighten the bolt for the stove's valve in order to stop the smell, they could over-tighten the bolt and cause damage to a seal. This can result in a constant gas leak.

A propane gas leak could create the risk of a fire or explosion.

The REV Group will notify owners by mail and instruct you to take your motorhome to a dealer to replace the defective hardware and perform a leak test. If you smell propane gas inside your motorhome, you should evacuate and turn off the gas supply immediately.