2018 Kia Sorento Recall

On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French.

These small errors do not affect vehicle safety.

This is not a recall. Kia has corrected the compliance label for all new vehicles.

On certain vehicles, wear inside the multi-function switch could cause the headlights to turn off suddenly when the switch is in the AUTO mode.

A loss of headlights would reduce visibility and could increase the risk of a crash.

Kia will notify owners by mail and advise you to take your vehicle to a dealership to replace certain parts in the multi-function switch. To reduce the safety risk, Kia recommends not to use the AUTO mode until the recall repairs have been completed.

Certain vehicles may be equipped with an accessory trailer wiring harness that could fail. Over time, water could leak into the control module and cause a short circuit. If this happens, there could be loss of the trailer lights. Note: This recall affects trailer wiring harness kits that may have been ordered at the time of a vehicle purchase, or purchased separately from a dealer as an aftermarket accessory.

A loss of trailer lights could make the trailer less visible. In addition, other drivers may not recognize that the vehicle ahead is braking or intends to turn. This could increase the risk of a crash.

Kia will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the trailer wiring harness. If the harness is from the lot (batch) affected by this problem, the dealer will replace it. Kia recommends that you should always check to ensure that trailer lights work properly before towing.

Kia Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure may cause a sudden loss of power with an inability to restart.

A sudden loss of engine power could increase the risk of a crash.

The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles repaired under Service Campaign SC023 already have this software update.

When the engine was replaced under warranty or under Kia's Product Improvement Campaign SC023, the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. A fuel leak could occur if the pipe was damaged, misaligned or improperly torqued during the recall repair.

Leaking fuel in the presence of an ignition source could increase the risk of a fire.

The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer for an inspection. If fuel leakage is detected, the fuel pipe will be replaced with a new one.

On certain vehicles, the bracket that secures the steering column assembly may have been improperly welded and could separate. If this occurs, a driver may notice a loose feeling and/or a loud clunking noise from the steering column while turning the steering wheel. Ultimately, this could cause a loss of steering control, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the cross cowl bar assembly to ensure the steering column assembly is properly secured.

A failure of this component (steering) may increase the risk of a crash or injury.

Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).

On certain vehicles, the inflator diffuser installed in certain side curtain air bag modules may not have been manufactured correctly. If the vehicle were involved in a crash that warranted side curtain airbag deployment, this could potentially lead to the diffuser detaching. If the diffuser were to detach, it could become a projectile in the occupant compartment, and could cause a tear that could result in the side curtain airbag to not fully inflate. Both of these conditions could increase the risk of injury in a crash. Correction: Dealers will replace both the right and left hand side curtain airbags.

A failure of this component (airbag) may increase the risk of a crash or injury.

Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).