Safety defect investigations, technical specifications, and manufacturer repair notices for Canadian owners.
Enter a VIN to identify your vehicle and find Canadian recall notices that may apply to its make, model and year. Confirm VIN-specific eligibility and repair status with the manufacturer.
Switch to another Mercury Sable model year.
Safety recall notices and repair campaigns registered for the 1992 Mercury Sable in Canada.
On certain vehicles located in Manitoba, Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador, the lower sub frame mount plate nut may corrode and fail due to exposure to road salt. This could result in loss of structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the sub frame which supports the engine and transmission, allows the rear corners of the sub frame to drop. Should both rear corners drop, steering control would be adversely affected. Correction: Dealers will install subframe rear mount bolts, reinforcement plate and plate nuts.
A failure of this component (steering) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
VEHICLES WITH 3.8 LITRE ENGINES THAT WERE INVOLVED IN SAFETY RECALL 95S22 (95-202) WERE MODIFIED WITH A MAXI-FUSE THAT DOES NOT PROVIDE THE INTENDED LEVEL OF PROTECTION FOR THE ENGINE COOLING FAN ELECTRICAL SYSTEM. ALSO, BECAUSE A SIMILAR MAXI-FUSE CIRCUIT WAS USED ON CERTAIN 1994-95 TAURUS/SABLE VEHICLES WITH 3.8 LITRE ENGINES, THESE VEHICLES WILL BE INCLUDED IN THIS RECALL. CORRECTION: A FUSED WIRING HARNESS THAT PROVIDES THE REQUIRED LEVEL OF PROTECTION WILL BE INSTALLED ON AFFECTED VEHICLES.
A failure of this component (electrical) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
DIRECT WATER SPRAY OR LONG TERM WET DRIVING CONDITIONS MAY CAUSE WATER TO ACCUMULATE IN THE SPEED CONTROL CABLE CONDUIT. UNDER COLD CONDITIONS THIS WATER COULD FREEZE AND PREVENT THE THROTTLE FROM RETURNING TO THE CLOSED POSITION WHEN THE SPEED CONTROL IS DISENGAGED. THIS COULD ADVERSELY AFFECT DRIVER CONTROL AND CREATE THE POTENTIAL FOR A VEHICLE CRASH. CORRECTION: MOISTURE WILL BE REMOVED FROM THE CABLE CONDUIT AND A BOOT WILL BE ADDED TO THE SPEED CONTROL CABLE TO PREVENT WATER ENTRY.
A failure of this component (engine) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
NOTE: 1992-94 TEMPO/TOPAZ WITH 3.0 LITRE ENGINES; 1994-95 TAURUS/SABLE (EXCEPT SHO) WITH 3.0 LITRE ENGINES; 1992-93 TAURUS/SABLE WITH 3.8 LITRE ENGINES; 1992-94 LINCOLN CONTINENTAL. THE ENGINE COOLING FAN MAY BECOME FROZEN IN PLACE BY SNOW, ICE OR SLUSH. IF THIS OCCURS AND THE COOLING FAN IS ACTIVATED, EITHER AUTOMATICALLY TO REDUCE COOLANT TEMPERATURE OR WHEN THE DEFROSTER IS TURNED ON, THE COOLING FAN WILL NOT ROTATE AND CAN OVERHEAT. THIS CAN DAMAGE THE FAN MOTOR, FAN, FAN WIRING AND SHROUD WITH THE POTENTIAL FOR SMOKE OR A FIRE TO RESULT. CORRECTION: IN SOME CASES, THE FUSE FOR THE COOLING FAN CIRCUIT WILL BE REPLACED WITH A SMALLER FUSE. IN OTHER CASES, A JUMPER HARNESS WITH DEDICATED CIRCUIT PROTECTION FOR THE COOLING FAN WILL BE INSTALLED.
A failure of this component (electrical) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
On certain vehicles with 3.0 Litre and 3.8 Litre engines, the body mounts on the rear corners of the subframe which supports the engine and transmission may become detached due to corrosion of the rear lower mount retaining plates, allowing the rear corners of the subframe to drop. Should this occur, steering could become very difficult, thereby adversely affecting vehicle control. Correction: modified lower body mounts and attaching bolts will be installed on affected vehicles.
A failure of this component (structure) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
NOTE: VEHICLES WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. VEHICLES WERE MANUFACTURED WITH INCORRECT ELECTRONIC ENGINE CONTROL (EEC) PROCESSORS. CORRECTION: EEC PROCESSOR WILL BE REPLACED ON AFFECTED VEHICLES.
A failure of this component (emissions) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
Note: Station wagon vehicles only. Young children left unattended in the vehicle could lock themselves in the footwell area of the rear-facing third seat (or the underfloor storage compartment in station wagons not equipped with the optional third seat). Once the compartment is closed, it cannot be opened from the inside, and there is the danger of air deprivation, excessive body heat and panic response to a child who may have closed himself or herself in the compartment. Correction: A modified latch will be installed which does not have a self-latching feature and allows the compartment cover to be pushed open from the inside.
A failure of this component (structure) may increase the risk of a crash or injury.
Authorized dealerships will inspect the vehicle and complete all necessary repairs free of charge (parts and labor).
Official Transport Canada safety campaigns, Canadian motor vehicle safety compliance standards and live VIN specifications.
Explore safety recall records by model year.